Jump to content

Black Arrow

From Wikipedia, the free encyclopedia

This is an old revision of this page, as edited by Tmassey (talk | contribs) at 17:14, 14 May 2009 (→Vehicle: Change paraffin to kerosene. While paraffin was barely technically correct, it is very confusing. Kerosene is far less ambiguous.). The present address (URL) is a permanent link to this revision, which may differ significantly from the current revision.

This article is about the rocket, for other uses see Black arrow (disambiguation)
Black Arrow
A mockup of the Black Arrow in the rocket park at Woomera.
FunctionCarrier rocket
ManufacturerRoyal Aircraft Establishment
Westland Aircraft
Country of origin United Kingdom
Size
Height13 metres (43 ft)[1]
Diameter2 metres (6 ft 7 in)[2]
Mass18,130 kilograms (39,970 lb)[1]
StagesThree
Capacity
Payload to 220 km LEO
Mass135 kilograms (298 lb)[2]
Payload to 500 km LEO
Mass102 kilograms (225 lb)[2]
Launch history
StatusRetired
Launch sitesWoomera LA-5B
Total launches4
Success(es)2
Failure(s)2
First flight27 June 1969[1]
Last flight28 October 1971[1]
First stage
Powered byGamma 8
Maximum thrust256.4 kilonewtons (57,600 lbf)
Specific impulse265 sec
Burn time131 seconds
PropellantRP-1/HTP
Second stage
Powered byGamma 2
Maximum thrust68.2 kilonewtons (15,300 lbf)
Specific impulse265 sec
Burn time116 seconds
PropellantRP-1/HTP
Third stage – Waxwing
Powered by1 Solid
Maximum thrust27.3 kilonewtons (6,100 lbf)
Specific impulse278 sec
Burn time55 seconds
PropellantSolid
[edit on Wikidata]

Black Arrow, officially capitalised BLACK ARROW,[3] was a British satellite carrier rocket. Developed during the 1960s, it was used for four launches between 1969 and 1971. Its final flight was the first successful orbital launch to be conducted by the United Kingdom, and placed the Prospero satellite into low Earth orbit.[2]

Black Arrow originated from studies by the Royal Aircraft Establishment for carrier rockets based on the Black Knight rocket.[4] It was fuelled by RP-1 kerosene and high test peroxide, a concentrated from of hydrogen peroxide.[5] The name Black Arrow came from the Ministry of Supply policy of assigning designations consisting of a colour and a noun, unofficially known as Rainbow Codes, to research programmes conducted by the Armed Forces.[3]

Development

Black Arrow originated from a Royal Aircraft Establishment proposal for a rocket capable of placing a 144 kilograms (317 lb) payload into low Earth orbit, in order to test systems designed for larger spacecraft. In the autumn of 1964, the programme was authorised by Conservative Aviation Minister Julian Amery, however following a general election in October, the incoming Labour government put the project on hold to reduce expenditure.[6]

Following another election, the government approved the continuation of the programme with several modifications, including the reduction of the test programme from five to three launches. The first launch was set for 1968.[7]

Most of the technology and systems used on Black Arrow had already been developed or flight-proven on the Black Knight rocket, or the Blue Steel missile.[4] Black Arrow was designed to reuse as much technology from the earlier programmes as possible in order to reduce costs, and simplify the development process.[2]

Initial development was conducted by Saunders-Roe, which merged into Westland Aircraft in 1964. Westland was subsequently the prime contractor for the Black Arrow, and assembled the first and second stages at East Cowes on the Isle of Wight. The first and second stage engines were built by Bristol Siddeley in Ansty. The engines were test fired at the factory before being shipped to the Isle of Wight, where they were integrated into the rocket and the first stage engines were fired again at High Down.[8] The third stage was built in Somerset by Bristol Aerojet, whilst the solid propellent was produced by the Explosives Research and Development Establishment in Waltham Abbey.[4] The stage was designed and integrated by the Rocket Propulsion Establishment in Westcott.[4]

Vehicle

Cutaway diagram

The first and second stages of the Black Arrow were fuelled by RP-1 kerosene, burnt using high test peroxide as an oxidiser.[5] Due to the lower volumetric specific energy of hydrogen peroxide than that of many other oxidisers, a larger oxidiser tank was required compared to many contemporary launch systems. The oxidiser tanks were located below the fuel tanks, following the practice of putting the more dense propellent at bottom in order to lower the centre of gravity and make the rocket easier to control. This arrangement had been pioneered by Germany and the United States, whereas the Soviet Union had placed oxidiser tanks above fuel tanks, allowing the lower tank to be filled first.

Attitude control on the first two stages was provided by thrust vectoring. The eight first stage combustion chambers were arranged in pairs which could gimbal either way along one axis. Two of the pairs were arranged perpendicular to the other two, and when all four pairs were used together, they provided roll, pitch and yaw control.[4] The second stage had two combustion chambers, which could gimbal along two axis, providing the same level of control. During a coast phase after second stage cut-off, the rocket was controlled by a reaction control system.[4] The third stage did not have an attitude control system, and was instead spin-stabilised.[2]

The first stage was powered by a single Gamma 8 engine, which burned for 127 seconds[2]. The Gamma 8 was an eight-chamber engine, derived from the Gamma 301 engine used on the Black Knight. It was 6.9 metres (23 ft) long, and had a diameter of 2 metres (6 ft 7 in), the same diameter as the French Coralie.[2] Coralie was used as the second stage of the Europa rocket, and the decision to give Black Arrow the same diameter as Coralie was taken in order to make it compatible with Blue Streak, which was used as the first stage of Europa.[2] This would have allowed Black Arrow's payload capacity to have been increased, and would also have allowed Britain to use the first stage of Black Arrow as a backup to the Coralie.[9] For this reason, all dimensions in the original specification were given in imperial units except the first stage diameter, which was given in metres.[2]

The first and second stages were connected by an interstage structure containing four Siskin IB separation and ullage motors, which separated and ignited seven seconds after the first stage had cut off. The interstage separated from the second stage six seconds later. The second stage, which was 2.9 metres (9 ft 6 in) long and measured 1.37 metres (4 ft 6 in) in diameter, was powered by a two-chamber Gamma 2 engine[10] which ignited shortly after the separation motors, and continued to burn for 123 seconds.[2] Three minutes after launch, during the second stage burn, the payload fairing separated.

The first two stages and fairing of R4

About 257 seconds into the flight, the second stage cut off, and the rocket entered a coast phase to apogee. Immediately after cut-off, the second stage attitude control system was pressurised. During the coast, the attitude control system was used to maintain the correct attitude for third stage separation. Towards the end of the coast period, the third stage was be spun up to a rate of 3 hertz (180 rpm) by means of six Imp rockets.[2] Five seconds later, the third stage separated,[4] and following ten more seconds of coasting, it ignited. The third stage was a Waxwing solid rocket motor, which burned for 55 seconds.

Just over a minute after the third stage had burned out, the payload was released, and gas generators were used to push the spacecraft and spent upper stage apart.[2] The delay between burnout and separation was intended to reduce the risk of recontact between the upper stage and payload due to residual thrust. Despite this, the upper stage of R3 collided with Prospero after the spacecraft had separated,[2] resulting to damage to one of the spacecraft's communications antennae,[11] however the spacecraft was still able to successfully complete its mission.[11] On the R3 launch, the ascent took 710 seconds (11.8 min) from liftoff to spacecraft separation.[2]


Although none were ever built, several derivatives of Black Arrow were also proposed, as ways of increasing its payload capacity. One proposal added eight Raven solid rocket motors from the Skylark programme to the first stage as booster rockets.[4] Another suggestion was to mount the entire rocket atop a Blue Streak missile,[2] whilst a third proposal involved replacing the Gamma engines with the more powerful Larch.[4]

Launches

The colour scheme used on all flights except R0

Four Black Arrows were launched between 1969 and 1971. The first two launches were demonstration flights, with battleship third stages and a boilerplate payload. On the first flight an electrical fault caused a pair of first stage combustion chambers to pivot back and forth.[12] Before it cleared the launch pad, the rocket was rolling erratically, and about a minute later it began to disintegrate. After the first stage engine failed, and the rocket began to fall back to earth, it was destroyed by range safety.[13] The second launch was successful. The first all-up launch on 2 September 1970 was the third launch of the Black Arrow, and Britain's first attempt to launch a satellite. The launch failed due to a leak in the second stage oxidiser pressurisation system, which caused it to cut out early. The third stage fired, but the rocket did not reach orbit, and re-entered over the Gulf of Carpentaria.[14] The fourth launch successfully orbited the Prospero satellite, making the United Kingdom the sixth nation to place a satellite into orbit by means of an indigenously developed carrier rocket. The satellite, also known as X-3, was named Prospero after the character Prospero in Shakespeare's The Tempest. The name was chosen as a reference events in the play, in which Prospero, a sorcerer, gives up his powers.[15] Prior to the cancellation of the Black Arrow programme, the satellite was to be named after Puck from A Midsummer Night's Dream.[5]

All four launches were conducted from Launch Area 5B at the Woomera Prohibited Area in Australia, which had previously been used as a test site for the Black Knight rocket. During the development programme, launch sites in Barbados, Uist and Norfolk were also considered.[2] The launch site at Uist was rejected as it was too inaccessible, and it was determined that there was a risk of a rocket launched from Norfolk dropping spent stages on an oil rig in the North Sea.[16]

Serial number Launch date/time (GMT) Payload Outcome Remarks
R0 28 June 1969, 22:58[1] None Failure Suborbital test of first and second stages, thrust vectoring failed[13]
R1 4 March 1970, 21:15[1] None Successful Suborbital test of first and second stages
R2 2 September 1970, 00:34[1] Orba[1] Failure Second stage failed to pressurise
R3 28 October 1971, 04:09[17] Prospero[17] Successful Successfully reached Earth orbit
R4 Not launched Preserved at the Science Museum in London[4]

Cancellation

Black Arrow R4 on display in the Science Museum

The cancellation of the Black Arrow project was announced in the House of Commons on 29 July 1971 by Minister of State for Trade and Industry Frederick Corfield. As the R3 rocket had already been shipped to the launch site, with the second stage having arrived three days earlier, permission was given for it to be launched.[2]

The programme was cancelled on economic grounds, as the Ministry of Defence decided that it would be cheaper to use the American Scout rocket, which had a similar payload capacity, for future launches.[18] Prior to the cancellation of Black Arrow, NASA had offered to launch British payloads for free, however this offer was withdrawn following the decision to cancel Black Arrow.[2]

The first stage of Black Arrow R3

The final Black Arrow to be completed was R4, which did not fly, and is preserved in the Science Museum, London, along with the flight spare for the Prospero satellite.[19] A replica of the Black Arrow rocket stands in the Rocket Park at Woomera. In addition, the remains of the first stage of Black Arrow R3 were recovered from the Anna Creek cattle station and are displayed in the William Creek Memorial Park.[20]

The launch facilities at Woomera were demolished within a year of the final flight,[4] and half of the engineers who had worked on the programme were laid off.[13] The X-4 satellite, which had been manifested for launch by Black Arrow R4, was eventually launched on 9 March 1974, by an American Scout D-1 rocket flying from Space Launch Complex 5 at the Vandenberg Air Force Base in California.[21]

As of 2009, the United Kingdom is the only country to have successfully developed and then abandoned a satellite launch capability.[22] All other countries to have developed such capability have retained it either through their own space programme, or in the case of France through its involvement in the Ariane programme.[22]

See also

Wikimedia Commons has media related to Black Arrow.

References

  1. ^ a b c d e f g h Wade, Mark. "Black Arrow". Encyclopedia Astronautica. Retrieved 2008-03-09.
  2. ^ a b c d e f g h i j k l m n o p q r s Hill, C. N. (2001). "Black Arrow". A Vertical Empire: The History of the UK Rocket and Space Programme, 1950-1971 (2006 ed.). London: Imperial College Press. pp. 155–188. ISBN 1-86094-268-7.
  3. ^ a b Gibson, Chris (2007). British Secret Projects: Hypersonics, Ramjets & Missiles (2007 ed.). England: Midland Publishing. ISBN 1-85780-258-6. {{cite book}}: Unknown parameter |coauthors= ignored (|author= suggested) (help)
  4. ^ a b c d e f g h i j k Millard, Douglas (2001). The Black Arrow Rocket: A History of a Satellite Launch Vehicle and its Engines. London: Science Museum. ISBN 1-900747-41-3.
  5. ^ a b c "British Space Race". Timeshift. BBC. BBC Four.
  6. ^ "Session 4". Black Arrow: British Rocket Science and the Cold War. Science Museum. Retrieved 2009-03-09.
  7. ^ "Session 5". Black Arrow: British Rocket Science and the Cold War. Science Museum. Retrieved 2009-03-09.
  8. ^ Rees, Bill. "High Down, Isle of Wight". Hengistbury Head: An Introduction. Retrieved 2009-03-09.
  9. ^ Hill, C. N. "BA Sectional". Space UK. Retrieved 2009-03-08.
  10. ^ "Gamma 2 Engine". Royal Aircraft Establishment Black Arrow Cutaway. Airspace. Retrieved 2009-03-04.
  11. ^ a b Parkin, L. W (1975-04). "The performance of Black Arrow in the launch of the Prospero satellite (Abstract)". SAO/NASA ADS Physics Abstract Service. Retrieved 2009-03-29. {{cite web}}: Check date values in: |date= (help); Unknown parameter |coauthors= ignored (|author= suggested) (help)
  12. ^ Harland, David M. (2005). Mason, John; Whyte, Alex (ed.). Space Systems Failures (2006 ed.). Berlin: Springer-Praxis. pp. 97–98. ISBN 0-387-21519-0. {{cite book}}: Unknown parameter |coauthors= ignored (|author= suggested) (help)CS1 maint: multiple names: editors list (link)
  13. ^ a b c Stracy, Mathew; Myerscough, Joe. Once We Had A Rocket (flv) (Documentary). Space.co.uk. Retrieved 2009-03-09.
  14. ^ Hill, C. N. "Black Arrow". SpaceUK. Retrieved 2009-03-09.
  15. ^ O'Brien, Stephen. "Black Arrow". Britain in Space. Retrieved 2009-03-09.
  16. ^ Hill, C. N. "North Sea". Black Arrow. SpaceUK. Retrieved 2009-03-09.
  17. ^ a b Crowe, C. T (1971-11-05). "Information Furnished in Conformity with General Assembly Resolution 1721 B (XVI) by States Launching Objects into Orbit or Beyond" (pdf). Committee on the Peaceful Uses of Outer Space. United Nations. Retrieved 2009-03-14.
  18. ^ Hill, C. N. "Black Arrow Cancellation". Space UK. Retrieved 2009-03-29.
  19. ^ "Black Arrow R4 launch vehicle, 1971". Science Museum. Retrieved 2009-03-09.
  20. ^ O'Brien, Stephen. "Image Archive". Britain in Space. Retrieved 2009-03-29.
  21. ^ Wade, Mark. "Scout". Encyclopedia Astronautica. Retrieved 2008-03-09.
  22. ^ a b Wheeler, Brian (2004-01-12). "Britain's first space pioneers". Magazine. BBC News Online. Retrieved 2009-03-09.


Retrieved from "https://en.wikipedia.org/w/index.php?title=Black_Arrow&oldid=289914993"